On my old buick lesabre I carry an extra coil pack and an extra ignition control module . Both are too easy to change and not bad expensive. I keep an extra coil pack for my wife's car also. Nice video!
HEY ZIPPO, BEREN A LONG TIME, HOPE YOUR DOING OK THESE DAYS, LIKED THE VIDEO ON THIS BIKE, I HAVE AN 04 VSTAR 1100 CLASSIC MYSELF, FIXING TO TAKE THE CARBS OFF AND REBUILD THEM TODAY, DID THE FUEL PUMP A FEW MONTHS AGO. TAKE CARE AND I LOOK FORWARD TO SEEING MORE OF YOUR VIDEOS SOON.
Heya Tim! The best change made to mt V Star was the addition of the beach bomber bars. It's the bike I ride most often over my two vintage Honda's (`73 CB350 F and `75 CB550 F) and my `04 Goldwing. Good luck on the carburetors buddy! Oh....Did you get your bike new? Did you get the Starter Recall taken care of? That was done on mine before I acquired it. Cheers!! Zip~
Love the sound of the bike. I agree need to get a second one and carry it along with tools needed to replace - but you already know that. Harder to replace than I thought it would be though. Great job. Take care. Thanks for the video.
Looks almost identical if not the same as the original 1 fitted to my Africa twin. Know to be a big problem I replaced mine at first with oem but died again. On the Africa twin forum everyone said fit a Facet pump, think they're actually American. Been spot on for many many yrs since!
I was thinking the same thing about carrying a spare. Especially at that price. If you pay for the extra one, then you know you will never need it. Ha Ha.
The fuel pump on my 2001 VStar 1100 Classic clicks and does pump gas but the clicking sound is very slight. I disconnected the hoses to each carb and there is gas flowing out of each during the timed priming cycle...doesn't seem to be much pressure and the pump sounds weak?...not sure. The engine idles fine but bogs and dies intermittently when throttled up. Most videos I've seen on the fuel pumps show a working pump with a much louder clicking sound. Is there a specific pressure that the pump must achieve to give proper flow rate to the carb when running?...Thanks
I'm having trouble on my 05 1100. I hear the fuel pump for about half a second vs that long 6 second ish fuel pump pressure stabilizing noise then it shuts off. Ran just fine the last time it was started, but now the fuel pump moves a little bit for about half a second, but the bike does not run. Crank no start. Maybe the fuel pump? I'm hoping it's not something else.
Zippo does the vent pipe need to be made so water want get into it. Just a short pipe under the seat so nothing will get in it. Great to see you again tell miss zippo i said hello. Love ya brother joe
I have the same bike and had the fuel pump replaced last month but it ended up dieing on me the other night and wont restart actting like its not getting fuel. I had just put gas in it and when i turn the key the pump doesn't engage. What other test can I do to be sure I got a bad fuel pump or what other suggestions do you have
i have that same pump but can be heard while running and riding i am losing power after 3rd gear should i replace the pump or could it be something else didnt have a problem until i noticed the pump running loudly
How did you diagnose this as bad did it up and quit on you? I’ve got a weird issue on my Vstar trying to chase down the rear cylinder cuts out around 1/4 throttle. Runs excellent some times other times it falls on its face.
Fuel pump can be heard when the key is turned on. It will cycle until the preset pressure is reached. As for the rear cylinder cutting out at times, the carburetor for that cylinder most likely needs rebuilt or you've got a spark plug on the way out. If you've done any modifications to the exhaust, these engines tend to run lean. The fix is installing appropriately sized jets best determined by a reputable motorcycle repair clinic/shop. Zip~
Is this the same on a 03 yamaha roadstar 1600 it will start after idles for 5 seconds n stall i thought it was bad gas at first drained the tank cleaned carb it idled a min and the stalls and wont start ??? Any info will be great thank you
I can only assume so, not knowing your bike directly. When you would first turn the key, do you recall hearing an audible rapid clicking that would stop after a few seconds? If so, chances are good that this is your problem as well. Good luck! Zip~
@@ZippoVarga i think so i tested it it pumped out real weak and it was clickin the whole time it dodnt sound like ur fresh new pump i put about 4k in 6 months and im at 42k its probably tome for a new pump thank you for ur vids and info
Great video. I’m gonna replace the fuel pump relay on my 03 1100. Hoping I don’t need to replace the pump. If I do, where did you get yours for $20? Also, what’s the brand of those blue handle clamps? Thanks
After carb cleaning, tank cleaning and tedious reassembly, I've discovered fuel hard leaking from the vent line roll over valve..... I've replaced the valve, still leaking Please help
Zippo, MotorcycleMD says you are wasting money on the cheap fuel pumps. The reason a fuel pump goes bad on a motorcycle is mostly due to not riding the motorcycle. Also, I read on a motorcycle forum that you can temporarily gravity feed the carbs but you will be lacking power.
I was trying to find a video on how to Remove or Bypass the Neutral Only Start Switch so I can start the bike by just pulling in the Clutch and starting it in gear, or push start it down the hill if the battery gets low... But it is VERY DANGEROUS TO HAVE IT ON!! My brother had a 2007 Vstar 1100 like the one that I'm looking to buy, and it stalled at a Red light an the the Sun was bright and he Couldn't see the Neutral Light and couldn't find Neutral and the traffic light turned green and he almost got run over so he got rid of the bike... I heard that it can be removed or bypassed because it Also causes problems with the Starter... So Please either make a video of how to remove it or bypass it or send me a link to one someone else has done, because I put it in the search and I can't find it, just get other ones like this one that isn't about that switch... But it is a Good video and I might need it later, but I need to know that I can fix that "Before" I spend all my money on a bike that is unsafe to drive with that switch in it... Thanks
nice video and you need boxing gloves if you keep fighting thing m8t lol but i use on pipes is Soluble Pipe Lubricant works a dream but keep up the good videos and hope ur shoulder get better m8t
I choose my routes very carefully and always keep my distance from 4 wheelers. When I'm being followed too close for my comfort, I put my hand down and wave followers to back off. If they don't, I pull over. 4 way intersections, I always let the 4 wheel vehicles go, even if they wave me on. As a rider, we've got to be UBER aware of our surroundings and always predict idiocy and ignorance. I can't say I've not had close calls. But I can say after over 35 years of riding, I've learned just about every idiot move 4 wheel vehicles can manage. But one can never let their guard down when on two wheels. No matter how visible you make your self, someone will simply not see you. But, the reward and freedom outweighs the danger factor. Not by much, but it definitely does. Cheers Chris! Great point with idiot drivers! Zip~
Less than that and when I got it it only had 4,500 miles on it and in perfect condition. On average, nice examples around me are selling for between $2,300 and $3,000
Worked out nice my friend. Sounds good and ready to ride. Now all we need is some nice weather lol.
You got that right!
On my old buick lesabre I carry an extra coil pack and an extra ignition control module . Both are too easy to change and not bad expensive. I keep an extra coil pack for my wife's car also. Nice video!
Great tip!
Pattern parts are always a challenge. Hope it keeps up at high speed.
Glad you're better.
Cheers
I hope so too!
HEY ZIPPO, BEREN A LONG TIME, HOPE YOUR DOING OK THESE DAYS, LIKED THE VIDEO ON THIS BIKE, I HAVE AN 04 VSTAR 1100 CLASSIC MYSELF, FIXING TO TAKE THE CARBS OFF AND REBUILD THEM TODAY, DID THE FUEL PUMP A FEW MONTHS AGO. TAKE CARE AND I LOOK FORWARD TO SEEING MORE OF YOUR VIDEOS SOON.
Heya Tim! The best change made to mt V Star was the addition of the beach bomber bars. It's the bike I ride most often over my two vintage Honda's (`73 CB350 F and `75 CB550 F) and my `04 Goldwing. Good luck on the carburetors buddy! Oh....Did you get your bike new? Did you get the Starter Recall taken care of? That was done on mine before I acquired it. Cheers!! Zip~
Love the sound of the bike. I agree need to get a second one and carry it along with tools needed to replace - but you already know that. Harder to replace than I thought it would be though. Great job. Take care. Thanks for the video.
Right on
@@ZippoVarga does it matter which line goes where on the pump?
@@mikegary6183 Yes
I subscribed your like the bob ross of fixing motorcycles!!! Thanks for your vid
Awesome! Thank you!
Looks almost identical if not the same as the original 1 fitted to my Africa twin. Know to be a big problem I replaced mine at first with oem but died again. On the Africa twin forum everyone said fit a Facet pump, think they're actually American. Been spot on for many many yrs since!
Awesome information! I will pick one up for sure!! Cheers rocks! Zip~
I was thinking the same thing about carrying a spare. Especially at that price. If you pay for the extra one, then you know you will never need it. Ha Ha.
The new one sounds more "active" I loved this trouble. Put the old one and a set of pliers in the box.
Bruce Pender There’s a problem in the cockpit!
The fuel pump on my 2001 VStar 1100 Classic clicks and does pump gas but the clicking sound is very slight. I disconnected the hoses to each carb and there is gas flowing out of each during the timed priming cycle...doesn't seem to be much pressure and the pump sounds weak?...not sure. The engine idles fine but bogs and dies intermittently when throttled up. Most videos I've seen on the fuel pumps show a working pump with a much louder clicking sound. Is there a specific pressure that the pump must achieve to give proper flow rate to the carb when running?...Thanks
It's not a high pressure pump Joe. Between 4-5 psi. Just enough to keep the fuel bowls full, but not so much as to over fill them. Zip~
Did this work for you long term? I have the same exact isssue as the person you are replying to. Thanks
Great video! The fuel pump on my 05 VStar 1100 Custom is leaking, so I need to replace it. How has the new fuel pump held up so far? Thank you,
So far so good Roberto!
@@ZippoVarga Appreciated. I just ordered the exact same pump for my bike. Regards,
I really like that bike. Its real sharp looking.
I keep telling Miss Zippo...I think I'll sell it, and she keeps telling me....Uh...No! lol Cheers! Zip~
Trying to do this job on the 650 and had to remove the seats, tank, airbox, sidecovers, all kinds of stuff. looks a lot easier on the 1100
Keep up the Great work my Friend.
Thanks, you too!
I'm having trouble on my 05 1100. I hear the fuel pump for about half a second vs that long 6 second ish fuel pump pressure stabilizing noise then it shuts off. Ran just fine the last time it was started, but now the fuel pump moves a little bit for about half a second, but the bike does not run. Crank no start. Maybe the fuel pump? I'm hoping it's not something else.
Definitely sounds like the fuel pump
Saludos como está.. Me puede decir dónde queda el relay de la bomba de gasolina nose cuál es..
Zippo does the vent pipe need to be made so water want get into it. Just a short pipe under the seat so nothing will get in it. Great to see you again tell miss zippo i said hello. Love ya brother joe
I have the same bike and had the fuel pump replaced last month but it ended up dieing on me the other night and wont restart actting like its not getting fuel. I had just put gas in it and when i turn the key the pump doesn't engage. What other test can I do to be sure I got a bad fuel pump or what other suggestions do you have
i have that same pump but can be heard while running and riding i am losing power after 3rd gear should i replace the pump or could it be something else didnt have a problem until i noticed the pump running loudly
That would be my guess Kip. Zip~
Okay thanks 🙏🏽
How did you diagnose this as bad did it up and quit on you? I’ve got a weird issue on my Vstar trying to chase down the rear cylinder cuts out around 1/4 throttle. Runs excellent some times other times it falls on its face.
Fuel pump can be heard when the key is turned on. It will cycle until the preset pressure is reached. As for the rear cylinder cutting out at times, the carburetor for that cylinder most likely needs rebuilt or you've got a spark plug on the way out. If you've done any modifications to the exhaust, these engines tend to run lean. The fix is installing appropriately sized jets best determined by a reputable motorcycle repair clinic/shop. Zip~
Is this the same on a 03 yamaha roadstar 1600 it will start after idles for 5 seconds n stall i thought it was bad gas at first drained the tank cleaned carb it idled a min and the stalls and wont start ??? Any info will be great thank you
I can only assume so, not knowing your bike directly. When you would first turn the key, do you recall hearing an audible rapid clicking that would stop after a few seconds? If so, chances are good that this is your problem as well. Good luck! Zip~
@@ZippoVarga yes very rapid clicking i got a pump in the mail its on its way thank you sir!! Ride safe!!
@@tkong35 I hope that solves your issue! Zip~
@@ZippoVarga i think so i tested it it pumped out real weak and it was clickin the whole time it dodnt sound like ur fresh new pump i put about 4k in 6 months and im at 42k its probably tome for a new pump thank you for ur vids and info
How did the pump hold up?
Still going strong!
Great video. I’m gonna replace the fuel pump relay on my 03 1100. Hoping I don’t need to replace the pump. If I do, where did you get yours for $20? Also, what’s the brand of those blue handle clamps? Thanks
Hey man! You probably already fixed it but eBay has em plan on replacing mine this week or so
After carb cleaning, tank cleaning and tedious reassembly, I've discovered fuel hard leaking from the vent line roll over valve..... I've replaced the valve, still leaking
Please help
Cool
Where you bought the pump? Could you please share the link?
How did you know your fuel pump was bad
Zippo, MotorcycleMD says you are wasting money on the cheap fuel pumps. The reason a fuel pump goes bad on a motorcycle is mostly due to not riding the motorcycle. Also, I read on a motorcycle forum that you can temporarily gravity feed the carbs but you will be lacking power.
Very good job
I was trying to find a video on how to Remove or Bypass the Neutral Only Start Switch so I can start the bike by just pulling in the Clutch and starting it in gear, or push start it down the hill if the battery gets low... But it is VERY DANGEROUS TO HAVE IT ON!! My brother had a 2007 Vstar 1100 like the one that I'm looking to buy, and it stalled at a Red light an the the Sun was bright and he Couldn't see the Neutral Light and couldn't find Neutral and the traffic light turned green and he almost got run over so he got rid of the bike... I heard that it can be removed or bypassed because it Also causes problems with the Starter... So Please either make a video of how to remove it or bypass it or send me a link to one someone else has done, because I put it in the search and I can't find it, just get other ones like this one that isn't about that switch... But it is a Good video and I might need it later, but I need to know that I can fix that "Before" I spend all my money on a bike that is unsafe to drive with that switch in it... Thanks
Mine will start by holding the clutch in while in gear
nice video and you need boxing gloves if you keep fighting thing m8t lol but i use on pipes is Soluble Pipe Lubricant works a dream but keep up the good videos and hope ur shoulder get better m8t
Nice Bike Zip! She’s a beaut. I’d never ride half these people where I’m from scare me with their terrible driving.
I choose my routes very carefully and always keep my distance from 4 wheelers. When I'm being followed too close for my comfort, I put my hand down and wave followers to back off. If they don't, I pull over. 4 way intersections, I always let the 4 wheel vehicles go, even if they wave me on. As a rider, we've got to be UBER aware of our surroundings and always predict idiocy and ignorance. I can't say I've not had close calls. But I can say after over 35 years of riding, I've learned just about every idiot move 4 wheel vehicles can manage. But one can never let their guard down when on two wheels. No matter how visible you make your self, someone will simply not see you. But, the reward and freedom outweighs the danger factor. Not by much, but it definitely does. Cheers Chris! Great point with idiot drivers! Zip~
How much a silly cheap? I found one online for $1,100... Need some work on it maybe
Less than that and when I got it it only had 4,500 miles on it and in perfect condition. On average, nice examples around me are selling for between $2,300 and $3,000
hi zippo im john jacob 1966 b10 what is the egg shape hole in dash for if you no let me now?
nevermind i feel stubbid for steering shift im sorry for wasting your time.
They are a nice bike, Same fix same bike, common problem don’t knows. Not my bike
Just replace the points in the fuel pump. Dont buy cheap Chinese stuff. Repalced my points in my roadstar and never had an issue
I keep receiving fuel pumps from eBay with the wrong plug in anyone know anything about this ?