Citroen C4 Grand Picasso P242F Particulate Filter Worn P208E P20F6 Denox System Blockage, Leak.
ฝัง
- เผยแพร่เมื่อ 5 ต.ค. 2024
- adblue injector replacement & DPF Cleaning
Launch UK products used in the video are available at www.launchtech...
for vehicle repair bookings email us at orileysautos@gmail.com
bookings only. not for questions or advice.
There is a recall on quite a few of these 1.6Hdi for the rust issue on the catalyst unit that this car also has in the flared connection flange. Tell the customer to check if his car is included in the recall and if he is lucky he'll get a new one.
Good for you to know Jimmy that some have that recall so refer your future customers to check with the dealer. You seem to get through rusted flanges quite often.
Also the seal on the Adblue injector falling apart is really common, you can just replace the seal because you can buy just the seal actually from PSA or wherever, if you want to save the customers some money and know for sure the injector isn't bad in some other way. But warm water clean and new seal and most injectors are like new.
PS: Checked VIN against Citroen database, sadly not covered under any recalls.
That's weird as it definitely have that corrosion there. Maybe worth checking with the dealership
The adblue rusts the exhaust from the inside. Well done the designer.
For the price of that Launch scan tool you would think they could put a rev counter somewhere on the screen and a way to set it at 3000 revs .
Great Video as always. That Adblue sounds like a right PITA. I have the same car but without the Adblue system, whenever the ‘Risk of Particulate Filter Blocking’ message comes up, I put a can of Redex DPF Cleaner in the Diesel and the message goes away for approx. 4 months, and then same again. It brings the DPF pressure down from 20 m/bar at idle to 5 m/bar. I have been doing this for 2 years, now at 180.000 miles, original DPF, EGR etc.
DPF master does it again, 👍👍
Thanks again!
Great video as usual. Did you check for pending recalls? Citroen replacing urea tank cap and catalyst +urea injector as recall on this vehicles. The cap is just another cap. Catalyst replacement is because of that kind of corrosion you have there. All free of charge.
Great job
In terms of the cat, what is so bad about wire brusing off and using JB weld or similar? It doesn't rust, strong enough to do the job, costs much less in orders of magnitude and is much easier. You could of taken the clip off, put some JB weld around the whole joint, covered in cling film and reapplied the clip. It would protect the rest of the rusting joining and probably last the life of the car.
Personally, I think there is a bit of a difference between what mechanics do when people are watching and what they do when they are not. I suspect reputation protection is probably driving that mindset but if you can justify a repair to be a reasonable one that will last a reasonable amount of time then it is wholly acceptable in my opinion. If it works, it works.
Love your videos.
I would have used some exhaust repair gum. Why wouldn't he have that in his van?
As above, I would have just left the van at home and gone to tesco and bought cling film
Very insightful video Jimmy, you are an Ace mechanic, thanks for your help and thanks to the commenter about JB Weld regarding the cat converter. Btw, what scanning device do you use?
Launch eurotab 3, he says it at the start of every video
Thanks@@tonyrice3348
With the P242F fault and given the mileage would it not be advisable to clean the dpf (or replace) before resetting the kms back to zero? I have the same fault on my C4GP, mechanic says although it is a calculated fault before resetting the dpf should be removed, cleaned and reinstalled (not cheap!)
With citroen the dpf usually says it need replacing at 120k when you look into it with it software.
Yes 👍🏻
What to do if I have 2 errors: P208E Denox System Circuit, Detection of a Blockage, and U1318: Communication fault with the built-in Systems Interface - communication not valid. Is it a reason of FAP regenerating every 120-240km?
You are a great mechanic. Can I ask what brand and version of diagnostic scanner you use?
Launch euro tab 3 £6300
Launch EuroTab Tree
@@chriswatson2407😂
Launch EuroTab lll
Is that the best diagnostic tool in the market?
Hi, how do you release the electrical connector from this injector. I can't quite see how to do it
How much fluid do you refill PAT fluid? Is 1L enough or full 4-5 L is needed for service refill. Thank you
2.5l
At 15:19 he said: About 2 & a bit liters in there.
hello, I’m looking for some help I have took it to a garage and they haven’t really come up with anything. What could be causing this These are my fault codes p1199 p0421 DPF pressure is very low 0.02 we have replaced the sensor but made no difference.
and cruise control doesn’t work
and the cars citroen c4 grand picasso 2.0 bluehdi
Jimmy…. Watching your vids on the vans you keep doing . My Vito 111( 1.6 Reno engine) won’t Rev above 3000 rpm when parked up… is this normal cos it’ll go higher than that when driving . No lights on dashboard at moment!!! Where are you based ??
It's normal
Master
What right minded person has a diesel car today !,,,, Go petrol 😄😄😄😄😄
Me 😅
TH-camr CarUk a car dealer basically said after 10 years old he won't touch a Citroen C4 Picasso
Bloody horrible cars
ok 🤣🤣
Typical french car, electrics ain't the best but the engines is brilliant the adlblue and eolys tank combined hasn't helped it over the years but I regualry see these engines in volvos mainly with 170k-300k. Volvos owners seam to be very particular with their maintainence.
@@beany1987 Electrics aren't the best... I best tell my two pugs on 250k miles to break their electrics. Eolys system is best in market. Lowers combustion temperature, cheaper DPF's, far lower oil dilution, dpf regen is quicker hence saves more fuel. Adblu... that's an issue on all cars due the crystallisation issues.
@@khalidacosta7133 you know about the adlblue and the eolys average Joe though doesn't, the only problems I have ever had with French cars is electrical. Airbag lights, electric handbrake switch failures recently, window motors and switches just my experience from working on them. My experiences with these and the electrical problems is on cars usually with 8+ years mileage doesn't really matter.
@@beany1987 Yeah... mine were from 1999 and 2009... so far more than 8+ years! The average joe doesn't need to know about Eolys, that is the job of the garage.
Would u say Jimmy that French Cars are the worst that was ever invented I'm talking about diesel of course.