BMW Battery Safety Terminals (BST) - Diagnosing and Repairing
ฝัง
- เผยแพร่เมื่อ 25 ส.ค. 2024
- www.euroautotra...
The Car Commando gives tips and tricks for BMW Battery Safety Terminal (BST) diagnosis and repair. Find more On Demand Technical Training videos and Technical reference Manuals at www.euroautotraining.com.
and that right there deserves a medal
well that intro was about 1:25 longer than it needed to be.
Facts
I salute you Car Commando
Interesting, my bmw '99 E39 528i has been having electrical power issues lately and today after I turned off my engine for about 2 minutes i tried starting up my car again and all the electrical power went completely dead, no dash lights, no power locks or even the windows worked. There was no way way a battery could drain that quick and completely dead in 2 minutes so i checked for loose cable connectors on the battery terminals and they were on fairly tight but what I discovered was when I wiggled the only positive battery cable itself all the electrical power turned back on, So your video could explain exactly what my electrical power problem is. I will look into it further tomorrow. Thanks for your video.
I have recently purchased 2002 e39 tourer i am having this problem gonna watch the vid now!
Thank you! Very helpful!
hi, ive got airbag and restraint sytem malfunction,the code that comes up is ( 9AFF Resistance firing circuit, safety battery terminal, too high ), the bst seems to be fine,ive cleaned every connection and had the codes cleared,but it comes back on after a short time, the charging output is about 14.5 volts from alternator when measured at the battery terminals,also car has been to BMW for a recall issue concerning a cover for the battery cable terminal in the trunk,cheers for your help
If you break the T-shaped bolt that allows the cable to clamp to the battery you cannot get one from BMW, they dont sell them separately from the cable... but you can go to a auto parts store that sells Standard Motor Product branded parts and ask for a BP59C, or the BWD branded part BH59B, or go to a NAPA and ask for a 718628. Dont overtighten, the torque needed is 5NM or 3.6 Ft Lbs.
1966Chevy2SS wym
do these things fail for no darn reason at all ? I have a BST on my 2002 e46, that hasnt blown, but is showing a "resistance too high" from the BST circuit. Any possibility of the black wire being loose or rusty i.e. is the resistance measured between that black box wire -> the yellow plug on the BST ? Thanks for the video, very helpful.
Thanks for the Great info.
super helpful
I have a 2006 BMW X3 got rear-ended,i try to started everything lights up and you can hear a click but it won't start,do you think that could be the issue the BST
there anyway to rig this to work temporarily until i get a new one?
I changed the cable of e60 550i, but with 5 minutes running the car, the BST Blow again, so I am afraid of changing, maybe a problem with ABS Module?
could heavy bass trigger this?
There anyway to rig this to work after its blown?
yes
Hi I need help ! I have a 2012 e92 335i & it won't start up the engine but it turn/on the power & the brake is stiff :((
Thank you for your video, can you provide the part number for BST repair kit please.this is what I got and it was rear ended and I got airbag code. BMW is selling it for $560. Thank you.
Great video .See you to the next..Gracias amigo
Make the intro shorter.
hello Thomas I just been hit on the road from the back and the car won't start but the radio and everything works except the engine is this what I need to replace I'm guessing seatbelt pretensioners exploded the airbags didn't went off but when you turn the key the engine warm run and I have the airbag warning light on
Did you get a brain damage at the same time ?
Hi will you be able to help me, l have my BMW's water damaged computer box replaced with an automatic computer lock-set. My car starts very well but the steering wheel doesn't unlock even though the engine is idling.The second thing the radiator fan keeps on running without shutting off. My car is a 2011 model, 320i, Petrol, manual sedan. The steering wheel just remains locked it doesn't turn. The car's ignition is a start-stop one with the remote key fob. Please help.
Fuck BST. Idc what they thought it could do but apparently it blows up after driving through a pot hole or a bump at 5 mph. Now the car doesn't start for literally no reason
My gahhdamn problem I hit a pothole n my shit cut off on me windows won’t roll up or down windshield wipers won’t go off no radio no crank or start 🤦♂️
y have the light check airbag red...... and i have this error.
battery savety terminal 1. what i have to change ..?
what caused yours to do that? that happened to me when I was hit and airbag was deployed. some sort of safety thing do the car doesn't start with a deployed airbag
Hey, The best ideas that I have checked out was on Volt daddy (just google it) Without a doubt the most helpful info on batteries and this type of stuff that i have found.
is this issue kill the battery???
Thx man. I changed the battery and take down that fuckilg little cable. The airbag and belt error wwent out!
Is this what would be happening to my honda prelude? I got into a minor accident hit the back of a semi going 5kmh my radiator was pushed in and damaged. I think the battery was damaged too im not sure also my key is stuck in the ignition won’t come out since I crashed.
No
Can this cause a light control module to fail?
U need to replace the positive cable
any advice on replacing a bst/power distribution block on a e90 with one from a year or 2 newer model?
replace the crash sensor and the Airbag module
@@BMWPROGRAMMINGJAMAICA im having problems with my e90 335xi 2009 my battery positive terminal wire the sensor was melted so I replaced it with a used one and after I di that my abs and 4x4 lights r on for good dnt know what going on
@@BMWPROGRAMMINGJAMAICA any help please 🙏
The car doesn't start when the BST fires. Your power windows and other accessories still has power.
Exactly, this happened to my 328xi. It won't start, but it has power.
Would this stop the starter from cranking while still having some lites in the dash, radio lites up but won't play
Yes it would
Very true got brake checked yesterday mine blew and carr won't fucking start airbags blasted for no reason
i just bought a bmw 2006 330i from the auction the car was hit lightly broken headlight no air bag deployed checked the bts and looked fine but i have no electric power what so ever in the cockpit can start the car as well, if i press the power on the radio it will turn on and the in dash the button that shows the k also lights up no christmas lights. please help me out what i should do i live in hamilton ontario.
Found this guy that sells a diy bts rapid kit on ebay and I bought a kit off him for like 65 dlls if any one need one is called BMW BATTERY BST DIY REPAIR KIT
This a battery SAFETY terminal. It's purpose is to keep you from being in a fireball of a car when you are in an accident. What is your life and lives of your passengers worth?
What are the chances of you getting rearended and instantly barbecued in the post-Pinto era?
BMW cooked up this idea not because you're in dire danger of being in a fireball from a rear end accident, but rather because BMW engineers needed to find a way to charge you $400 for a battery cable, as if their intelligent battery system requiring you to electronically "register" a new battery with your car wasn't a sufficiently profitable dealer service magnet. My 1988 BMW 750iL has neither of these bizarre concepts baked into it. i am alive, well, as well as physically and economically healthy without them.
That BST saved my ass 👍
Air bag codes
2 minutes in and it's commercials -- not even video, it's still illustrations and audio
T Smith Yes. And it doesn't really improve. Its a good indicator of the overall style & content.
This is so annoying.. I’m having this problem on my first fucking bimmer.... bummer I should of stick with Mercedes 🙄
if it's the kit pn 61128387512, I'm seeing prices around $400. I sure would be interested to find the "half of two hundred" price! or, maybe there's a different pn?
61123
3.40 - If the BST blows the car will not start because it is the starter cable that has been disconnected by it.
Mine started just has codes
Geoff Crabtree yo mine crank turn all the lights on but I won’t star
Omg the intro half of the video 🤦♂️
That intro is too loooooonnnnnngggggg get on with it already
WiggleWorx lmaooo
Not true
Good way to drown if car goes in water and you can't roll the windows down quickly.
Rudy Linhub Electric windows still works. It’s only the main positive cable to the motor that is disconnected.
iklooveui juyesca ioplo ki bmw nji german kiop kisuyz europa ni amerik
sound like bill Cosby a little bit
Please do away with the time-wasting intro music.
Whit this intro you get suicide skils...
WTF was this? LMAO!!