ZF5HP19FL transmission Passat TDI tear down and rebuild tips. Tiger Transmissions.
ฝัง
- เผยแพร่เมื่อ 29 ส.ค. 2024
- 1997-2007 Volkswagen Passat/Audi/Porche Transmission ZF5hp19FL. Lots of parts for sale on these units at tigertransmissions.com. Passat diesel TDI zf5hp19fl transmission and turbo gas.
Good info thanks. For your pull tool maybe try something like this. In order...Bolt head, 1/2 washer, 1" washer. Get a generic lawnmower pull handle. Drill a hole in it and put the bolt through hole. You may need to cut off the bottom tube part of the mower handle. Take a piece of brake line or other rubber hose and slide over the bolt. Say 1/2" long. That is just to keep all the parts together when you sit it down. You may need a thinner hose then put a larger diameter hose over the first hose.
You make a good video with practical tips on what to watch out for.
I have an EYK . Reverse feels like it engages but freewheels when power is applied. Everything else is fine. Local mechanic says a cracked drum causes that.
Congratulations...
Good job.
Thanks.
I am in Brazil 🇧🇷
Ponta grossa city
Thanks Joshua, interesting video.
Subscribed,
Ross
Hello please can you help me in finding the name or part number for the 5 rubber seals you pulled out. Kind regards
Thanks for the video!
Great video, I have a 2003 Passat AWD with a dead 30 valve V6 engine and I would like to know if its possible to pull off the rear diff off the AWD transmission and swap it on an 2005 Passat TDI FWD transmission in order to make the diesel AWD. Is this possible with these transmissions or will the gears not work?
Hi Joshua, I have passat with 5hp 19 transmission, the car was flooded, and the TCU was dead, the car worked in limp mode, he used it like that for a while forward 3d gear an reverse working fine, after I bought it from him I found the dead TCU, there was a lot of corrosion on the plug also, I cleaned it and after that the car works normally forward, changes gears smoothly but the reverse only works when the engine is idling, as soon as I touch the acceleration it seems to disengage and acts as neutral, if I release the acceleration it goes in reverse, other simtoms, when cold in reverse there is only a bump even at idle and car stops, move from N to R and moves a little and disangages, when hot reverse works at idle, it even goes uphill, other than that, if I remove the TCU reverse seems to work fine, I can accelerate even when cold. Hope you read this, what do you think?
Can you confirm every part can swap out with the GMR diesel transmission except the gears? You mentioned "the groove for the snap ring is a lot higher in the diesel" is that part one of the gears? I assume that is because the clutch pack is thicker, but is there a higher snap ring groove included on all ZF5hp19FL?
My trans is leaking at front by the TC. I'll probably contact your business for a rebuild job or to buy a remanufactured unit. Mine is a tdi with 176k miles.
Yes 615-855-7420
grear work
i have same transmission
the problem is no reverse on it
quistion is what cauose this problem
thank you from syria
Got a 5HP19 TDI trans, TCC lockup failure, with code. Two new converters (OEM), now TCC lockup solenoid, new Transgo pump valve. Still no fix, actually worse now. I suspect leak somewhere. Have you run across a TCC lockup issue on these that wasn't fixed with a new converter? Thanks!
is there a rear main seal on this transmission
Have you thought about drilling a hole in some round stock to make a pull handle for the seals, it’d give you something to pull on and should stay put while you run the bolt in
Could you point me in a direction on a 2005 TDI Passat? It’s slipping g in first gear only when hot. All other gears work great.
Hello, great video.
Question, when installing the 5 rubber pieces under the valve body, are they installed flat? Mine are around a 1/8 higher. Will screwing the valve body back in seat them? Thanks
Gary
2005 audi a4 quattro 5hp19 FLA.
Hola soy de España,tienes una caja entera para vender? O solo piezas? La mia es 5hp19 de porche
Gracias
P0731, gear 1 incorrect ratio. Fluid and filter are due to and will be done. Or can you say from expierence that a clutch pack is bad? Car drives and pulls and does not slip in 1st, only goes into safe mode when skidding on unpaved road while give it full beans. When safe mode, Reverse works normally.
I have the same code you ever figure out what the issue was ?
@@cdubskiii760 I first renewed the oil and filter. But that didn’t work. It indeed ended up the clutch pack. It’s a Audi S6 C5 tiptronic Quattro.
@@cdubskiii760 btw I say the clutch pack, but I also replaced the same time the torque converter. This one was also bad. I had a vibration whilst accelerating. Could be that too tho!
@@FlightSimXtreem I have vibration while accelerating too and at idle, which makes me think torque converter
Hi
I have a problem with my gearbox from my audi a6 c5 2.8 .
I put the Vag Com on and I got this error...
00293 - Multi-Function Switch (F125)
27-10 Implausible Signal - Intermitent
The PRND are all red
The car only drive in 1st gear and reverse
If you can help me with some information I will be very grateful.
Thanks in advance and greetings from Spain!
need switch side of transmission left side. You can drill out rivets and clean contacts . Use nuts and screws when refitting
Nice job! Question - is passat 2000, 1.9TDI, TCM P/N 3B0 927 156 P, is G182 Hall sensor type or induction type?? Nowhere to be found.
Hi! I have audi a6 (2001) with tiptronic ZF 5hp19FLA transmission... The problem is, that now i cant drive off... i can put in any gear but it simply wont drive off...
hi there nice video, I will work on one tomorrow. I dropped mine cause my TClockup failed, seal broken but other brand new reason was reverse. Cold OK , warm was either go till accelerate then no GO or no go but when accelerate it was big Go9tires squeal. Now I just dropped it and thought that alluminum drum will be broken bot seems ok, wonder where else could be Reverse problem ? Any tips?
Is there any chance you could tell me what the small hole is that is inside the bell housing at the bottom left corner? Ive got a bad leak that only leaks at high speeds and when it leaks it pours. The pump bushing and seal look to be good. No movement in the bushing.
Hi. Got a 04 passat 1.8 gas awd, ran low on fluid due to radiator leak. Went into limp mode , fixed leak. Refilled tranny, cleared codes in computer. Now when shifting up or down through gears its over reving and banging in each gear and banging when i downshifts. Is the tranny done. Thanks
I have arrived to that poor will the transmission on a front-wheel drive you work for a 4motion
I have a 2007 cayman that has this transmission and its making a loud grinding noise when decelerating. When accelerating it works perfect and it shifts well. Have you ever come across something like this. For sure the grinding sound is coming from the transaxle.
Yes usually comes from the Differential on the transmission. You need to check the oil in it it’s separate from the transmission oil.
Bearings could be shot in the diff
@@tigertransmissions Thank you!
Can you please help me out with the vw passat 1.8t automatic gear box when i diagnosed it it shows me incorrect gear ratio can you fix it
could i have your contact for a gearbox transmission vw passat 1.9 TDI 2003 automatic
Hello Joshua. I have same transmission as in video. 2003 Passat 1.8T
I changed fluid and filter, even used Ravenol fluid and German filter from BlauParts.
About a month later, heard a woosh sound, like tranny was sucking air. Would low fluid cause that, or did I put too much fluid in?
It shifted fine, but then 3 months later, the 1-2 shift will screech loudly every time until car is warmed up.
Am I destroying it by driving everyday?
Also, I’m at 177,000 miles
Can you put this valve body on a TDI one? Do they match? Just the valve body? Are the solenoids the same? WHat parts are same from 1.8 to 1.9tdi?
Yes it will work. The whole valve body will work
I know this is an old video. Not sure if you check comments still. But you say all the parts are the same except the ears on the rear. SO If I have a bad Diesel trans I could put a 1.8T trans in it and just switch the rear gears? Sounds to good to be true but that but sounds like that was what you where saying.
Should work fine. Change the rear gear set and slap it in. Probably shouldn't if you were pushing a fair bit of power through it, but stock it will work just fine
No you can’t change the rear gear set. They won’t fit, the cases are drilled differently in the back where the bearings ride, because the gears are different sizes. I’ve tried this before.
@@tigertransmissions Thanks for the correction!
If I bought a used 2003 transmissions for my 02 passat 1.8t both are gas do I need the transmission computer from the donor car
No
Where do you get parts? I am looking for a rebuild kit. I have a 2005 Passat tdi and it doesn’t move at all in any gear. I think it might be empty of fluid. I am most likely going to get a junkyard trans and rebuild it then to swap it. I also have a friend that has the same year Passat that he is getting rid of could I use parts from that trans if some are damaged?
Lee Rupert yes if it’s a diesel
It’s not a diesel. But besides the gears in the back there are parts that can be used. Also is there anything other tools you recommend other then what you used in the video.
I have an issue with my audi a4 b5 1.8 transmission
Can you used the turbo charged transmission on the none turbo engine
I have few of tdi tranys for parts or core. Wanted to know if anyone wants them.
b13nissan what do you want for them?
@@tigertransmissions i would like $200ea
b13nissan okay where are you located?
@@tigertransmissions seattle area