TATA SAFARI OVERHEATING PROBLEM |ENGINE OVERHEATING PROBLEM |ENGINE OVERHEATING PROBLEM FIX
ฝัง
- เผยแพร่เมื่อ 6 ต.ค. 2024
- how to check a car that overheats
thermostat valve is located on right side under the turbocharger , rear side is elbow outflow channel
sorry for wrong info
~-~~-~~~-~~-~
Please watch: "TATA SAFARI SERVICE LIGHT"
• TATA SAFARI DICOR SERV...
OR
visit www.torqueheadsblog.in
~-~~-~~~-~~-~
Very helpful and informative.
Thank you so much.
Please make more video.
Excellent video & information. Expecting more videos like this. MAY GOD BLESS YOU TO MOVE FORWARD WITH GREAT SUCCESS ........SHIBU DEVARAJAN, an ex: proud TATA employe, Louvre hotels group, UAE.
you need to check the engine seal kit also. If engine is overheating and raditor boiling issues comes frequently, your engine gasket is having some leak. If so, engine may sieze.....
Is it a good idea to change the thermostat valve thingy if I'm buying a used 9yr old Safari? No problems right now
Sir please sfary dicor 2.2 engine ke bare me bataeye
Kya ye dusre engine ki tulna me Kam karykusal or adhik kharabi nikalne wala hota hai
Best knowledge ever i seen
Sir could you tell me at what speed does the fan run.
And when the car is in still position does the fan spin or when the car is in motion it starts.
Is that Toyo radiator cap ? , I need to replace it ,in my safari ,as the front rubber part is broken . But its BEHR make , have to check if its available now
sir Central locking te v video bnado 🙏
Ok sir , next video pakka
AC vent se HOT AIR AA RAHI HAI MERI SAFARI MEI
Headgasket ka kaam bhi krvadiya hai
Radiator bhi clean kradiya hai
Paani bhi full hai
Par phir bhi AC VENT SE HOT AIR AAJATI HAI KUCH TYM CAR CHLNE K BAAD
Hello sir
All relays/fuses are fine still radiator fan is not working … in safari dicor
My safari was over heated and it turned off by itself... Now I've done 650 kms run in one day after the over heating issue..all I can hear is a knocking sound from the upper part of engine..but the car runs well... Got 15 kmpl ,no service light..just the sound....what should I do please suggest
I have Storme 2015 88k driven .... Usme cold weather m temperatures neeche jaata rehta h.. Mne OEM thermostat valve lgwa liya...
Agr truck walo ki trah radiator ki front air blocked kr deta hu toa sab OK rehta h
1 - agr temperature sensor error hota toa heater kaam krta... Plz help me 🙏
Sir,when u on ac,should radiator fan start immediately or will it only start when a certain temp is reached sir???
I think it should be start wen desired temp reach ...
Depends upon vehicle to vehicle
Some have a dedicated condenser fan so radiator fan doesn't kick in
Others which doesn't have a condenser fan , the radiator fan compansate as a condenser fan regardless of engine temp.
Please tell me the right answer of pickup problem my safari run 3 to 5 km in good speed and then gets heatup speed gets low and in hilly areas safari can not drive in good speed
Nice video sir.. Bt sir meri safari ma Thrmostate valve rt side ma h.. Jaha AC compressr hota h..
Ji wahi hai merse galti ho gai ,
Peche sirf elbow channel hai
Chalte chalte 1st gear lagane se awaaz ate hai bahut xyda jitne speed hogee utne awaaz ate hai rukne ke baad gear ache se lagte hai aur ek sawal ha bhai steering bahut xyda hilte hai jaisa lagta hai steering he toot jayegaa gaadi unbalance hoti hai tata safari 2.2 vtt 2009 2 wheel drive
Sir gear oil check lo ek bar and car ko alignment and wheel balancing ke lie le jao , agar wo thek ho to fir steering stabilizer strut khrab hai apki car ki
Hello Over heating problem then low pick up . Changed radiator , thermostat , water pump . temperature sensor , still over heating and coolant spraying out through reservoir tank . Even after parked for 2 weeks still radiator cap has pressure when i open the cap and coolant coming out .. is there any suggestions to fix or look for . Please help
Sir i have a doubt , considering you already changed the radiator and waterpump.
Have you checked the oil ?
Because the chances are that after overheating maybe the head gasket got compromised .
Check oil cap for oil coolant mixing
brother... at times when m driving my 2.2 dicor... specially in long traffic jams, shimla route p jam... gaadi band ho jaati h... i crank again it starts bt aisaa feel hotaa hai ki garam hoke band ho rahii h?? Can u suggest the reason aur ye hota h temperature half pahunchne k baad hii....
Things to check
1 battery terminals
2 temperature of vehicle ( does it start to rise ?)
3 fuses (for loose fuse)
It also sounds like a ecu overheat as it has a protection circut , it can shut off ( very rare) but can happen
Any lights on dashboard cluster ?
Bhai, i have a few Very basic doubts..
How do i know IF my Tata safari dicor is overheating?
What are the visual indicators?
1) Does the dashboard show up any lights to indicate it?
2) My temprature needle in the dashboard stays in the middle, or very slightly just half a degree to the right of the middle and holds steady there. ALSO even in summer, the temprature needle in the dashboard slowly rises up and settles in the middle. It doesn't reach there sooner. Could it be an issue with temperature sensor? It is this a normal behaviour.
There are no problems as such, but just wanted to check for any overheating symptoms.
Please advise
Sir its normal behaviour, it should stay somewhere in middle
Temperature indicator reaching midline very easily. Earlier it used to hover between 0 and midline. Coolant is full. It's dicor 2.2 vtt 2008. Sucking too much engine oil. No black smoke though. The 'service' indicator showing these days. Engine running smoothly though.
What could be the reasons? Following you since 4 years.
Sir any work done on engine recently ?
@@yourDIYneedsNo. I only did the suspension but that too wasn't complete. Problem persists with the wheel alignment due to the idler arm bracket. It seems the TASS these days ignore or hide(depending on the Safari owner's IQ) any problem on the safari dicor that requires spare parts which are locally unavailable.
The heating problem is gone for the time being. It required to mix some water in the radiator. I doubt it might recur during a long trip.
The engine sound/smoothness changes every time I fill fuel from different sources. Right now, it is not that smooth. It sounds like a bad throat. I was thinking of trying the cleaning of the MAF sensor with cotton soaked in spirit as you showed in a video. If it's related.
Fuel quality effects the engine refinement quite evidently , cleaning out MAF will help the car to read the air exactly and will add fuel accordingly. , Fans running ?
TASS are quite famous for their things 😅😅
Radiator fans ain't running.
Sir have a look at the thermostat switch . And fuse , one out of those two will be the reason , considering the fan motor is ok
Once again vry good information bhai ...
Sar Ji ek Safari hit ho rahi hai radiator ki saaf karva diya kya thermostat valve bhi nikal Diya gaya hai fir bhi hit ho rahi
Radiator chowk ho sakta hai , ya phir water pump sahi se kaam nahi kar raha
brother ac is not switching on and condenser fan is repeatedly getting on and off
what might be the reason could you kindly please reply.
Had you checked the fuse and relay for ac compressor ?
Bhai safari k sentral lock k repair k bare m 1video dal do plzzzz
Ok sir
Sir, radiator fan ki speed dikhayiye please
very nice
Safari Dicor engine overhaul total cost kitna hai
Sir dil❤se namaskar sir ek help chaye thi meri dicor m jo meter m temperature🌡️ show hota hai uski suii 10km chalne k baad mein beech m chali jati hai to vo overheating problem hai ya normal hai engine k liye or sir fans b chl jata hai jab engine garam ho jata hai plz btana sir
Sir normal hai
@@yourDIYneeds or sir aggr beech se sui halki si aage jaye bilkul bhaut halki si fir b problem hai kiya sir
Sir 10% tak upar ya neche hone me koi dikkat nahi hai
@@yourDIYneeds thnx sir ji👍❤
फेन कब चालू होते हैं कृप्या बताये
Sir apne aap hota hai , jab car apne temp pe aa jati hai
Bro, driver seat k aage jo radiator fan kaise chalta hai? Gadi k chalne par ?
Sir radiator fan runs according to the engine core temperature .
@@yourDIYneeds thanks Bro. I have Safari Dicor 2011 model. Your channel is really helpful.
sir mujhe altenator ka cut out a
nd.
radiator fan stand chaiyeh price bata skate hai ap sirr pls boliyega
nd clutch plate presure plate
nd clutch wiring sbka dam kitna padega sir
Sir 99rpm.com
Goo day sir how are you, can you please assist me. I have a tata 2.2 decor and i bought it with the temperature gauge not working. i want to fix it myself can you advice me how to do this please
Sir have a look at the last video you will have an idea
i checked but i dont understand the langauge
You have to locate the thermostat sensor first so that you can check fir wiring problems then if it is not that part then maybe the motor inside the cluster or maybe the cluster wiring issues can be a reason
ok thank you so much
hello how do you reset the ecu on the tata safari also known as zenon
Xenon ka engine b same huta hai na bhai..
Main Saudi se hun..
But yahan pe parts nahi milta jaldi se...
Ji sir 2.2 hi ata hai same safari wala
Sir waha ka to nahi pta but i guess aap yaha se order kar sakte hai online
Sir mare pass 2,2 dicor tata safari ha 2008 model usme heating ki problem a rahe ha jase temp up ho jata ha or kush he time me temp metor down ho jata ha please batao
Sir over heat ho rahi hai ya sirf meter galat dikha raha hai ?
Meri gaddi mei cold start pe 2 point hote hai temperture ke phir 1 ya 2 kilometer chalne ke baad 4 ho jate hai point yani ki half temperture jo jata hai....iska matlab mera temperture sensor sahi working kar raha hai na ?
Sir temp. Half se upar nahi jana chaiye , agar wo us se upar nahi jaa raha to sab sahi hai
@@yourDIYneeds agar cold start karte hai jab jo 2 point hote hai vo hi rahe or half tak na aaye toh ??
Sir wo , maybe apki ko temp. Gauge ki needle hai wo atak rahi hogi , islea hai , or maybe temp. Sensor ki problem .
Agar needle ki ya sensor ki dikkat hai to car ko koi problem nahi hogi , lekin gar temp. Sahi me operating temperature tak nahi aa raha hai to apko fuel economy kam milegi gaadi se
Kuki average , pickup , performance sab cheje operating temperature pe hi best hoti hai
@@yourDIYneeds nahi sir sab thik hai temp operating temp tak aata hai...mai toh sirf isliye puch raha hu ki incase tempeture apne normal temperture pe na aaye toh temperture sensor kharab hone ki dikkat hoti hai vo ?
Sir , sensor ya cluster me needle , dono me se ek chej
Nice bhai
Ye co driver ki taraf ATF oil ka use kya hota hai??
Wo low hogaya hai,usse kya problem hoti hai
Sir power steering fluid hai wo , ATF and PSF same hi hote hai . Top up kar lijiye
@@yourDIYneeds transmission oil hi hota hai na ye???
Sir automatic transmission
my temperature meter needle remains at center of meter when optimum temperature reached.is this normal?
Yes sir perfectly normal
Meri Gadi band Karne pe coolant leak hone lgata h..overheating ka koi issue nh h tb bhi.
Sir leak minor hai islea effect ni karra
@@yourDIYneeds sir finally leak mil gya 2 hose pipe the change krwa liye...problm solved..thanks a lot bhai
Most welcome
Some videos on sumo victa
Sir 70% is same
Sir meri safari dicor kal 18km chlne pr hi thoda overheat ho gai, AC ki cooling bilkul nhi aarhi thi, kush time k vad race Lena shod Diya fir Apne aap 60. Speed pr chlti rhi but race nhi le rhi thi,
,Maine check Kiya radiator me coolent 2ltr kam ho chuka tha,but side vala tank me coolent tha,fir vo radiator me kyu nhi gya Hoga???
2.( Radiator cap Vali rubber fat chuki hai j new milegi ja radiator cap hi new milta hai,, ese hi chlaa skta Hu gaadi?)
3. Pehle v drive krte time temperature normal se low hone lgta hai kaafi time long drive pr,
Koi problem vali light nhi aarhi
Koi jyada badi problem aagai hogai kya, please reply kre,,nd solutions btaaye
Sir wo coolant expansion tank hai usme coolant sirf jata hai wapis nahi ata !
2 radiator cap new mil jaegi 1.0 rating wali lana
3 car me se thermostat nikal rakha hoga islea long drive pe temp low hora hoga
@@yourDIYneeds thanks for reply Sir
@@yourDIYneeds Sir engine head gasket replacement to nhi krvana padega?? Coolent kam ho rha hai 6-7 km chlne par 1L kam hogya,,,,,j sirf cap khrav hone ki vjy se kam huaa Hoga?? Abhi refill krne k vaad check kra hai
Sir engine oil cap ko check karo , uske andar wali side ( cap pe ) white layer hai ?
@@yourDIYneeds Sir, abhi check kra white layer nhi hai,Cap k andr...
Aaj Maine radiator cap change krdiya, pehle jaisa nhi Mila, quality jyada Achi nhi hai but koi option nhi tha to lga liya
Hi sir mere pass tata indica ev2 lx cr4 dicore ingine car he but o 10-15 kilometer jane ke bad uska temreture high ho jata he or ac use kiya to thode hi time me tempreture high hota he or sir me jab bhi car leke bahar jana chahta hu to muje usme pani check karna padta he tab rediator me 1.5-2 leter pani bethata he.hr time muje kidhar bhi car leke jana ho to usme pehle itna pani dalna padta he.or fir me gadi band karta hu to uska jo fan he 5 minute tak chalta hi rehta he.
Mene bohat fiter logo ko dikhaya pr kahi proper solution nhi mila.mene sir bohot paisa kharch kiya phir bhi problem solve nhi hua.
Please sir muje kya problem he o batayiye or uspe proper solition bhi batayiye
Sir kahi se leak hai ?
Ek baar pura speedometer k barey mey bolo sir
My safari dicor was overheating because of haus pipe leakage , i got it changed at Tata motors service centre itself everything was good for 2-3 days and again the car overheated and stopped amidst the road , then i stopped the car for 30 minutes then i took it to service centre ,we were using all water to check if the leakage is still there but there was no leakage and the mechanic at tata said he cant figure out what’s the reason for that, they also used a scanner but there was no electric fault 🤦🏻♂️
Sir most probably a stuck thermostat valve is the reason .
@@yourDIYneeds How can we get it done ? Coz they have told me to visit again they want to check the radiator if there is any choking in it!
Sir thermostat valve is present inside a housing which is on the driver side under the turbo
Sir Tata aria ki video shot
Sir coolent aur water ka kitna ratio hona chahiye.??
Coolant - 50%
Distilled water- 50%
@@yourDIYneeds thnx sir.. Sir agr totally coolent daalenge to kya problm hoskti h..
Compromised cooling
@@yourDIYneedsCompromised cooling.?? Sir Clear ni hua..
Sir car sahi se cooling nahi kar paegi
Safari ca radiator fan kitne Temperature per on Hona chahie plz reply
90-95°C
sir meri car ki power kyu ja rahi hai bar bar maine mechanic se dikhaya toh usne bola car ki wring change hogi puri aur 20 thousand lagega
lekin mujhe sale karni hai car
phir maine ek aur mechanic ke pass gya usko bola koi jugar laga do nd usne
ek switch laga diya bola gari offf krne ke badd isee off krdo car me power ni jaegi aur kitne v dino tk laga kr rakho switch on krne ke badd car start ho jaegi
bt wo v fail.ho gya 4 din badd car start ki toh start ni hui safari ab mai kya karu pls help
Sir ise paracetic battery drain kehte hai
Isko thek karne ke liye poori gaadi ko sahi se check karna padega
Mostly se self solinoid ki dikkat hoti hai
@@yourDIYneeds apke pass lekr aau kya 😂
bhai maine autocop ki centeral lock lagayi hai mechanic ne bola wo v power le skti hai issi liye uska connection kat kr ke new battery lga diya ab dekhta hu kya hota hai
aur sir agr self solinoid ki dikkat hoti toh car start hi ni hoti n kabhi
Sir hone ko ye self ho sakta hai
Remote locking
Music system amplifier
Inme se kuch bhi ho sakta hai kyuki ye teeno cheje ye kaam kar sakti hai
@@yourDIYneeds sir toh ye aur sb car me kyu ni hota mere sath hi kyu ☹️☹️☹️☹️☹️☹️☹️
Nice video
Coolant made of athelene glycol.
Sent you an email 4 days ago. No response till now
Bhai mere me every time center se thoda jada reheta hai koi problem hai kya plz reply
Sir problem to nahi hai , lekin problem ki starting ho sakti hai ye ,
Aap ek bar cooling system ko ache se flush kar ke , naya coolant daal le , most probably apki problem solve ho jaegi
@@yourDIYneeds bro mene radiator clean karke naya coolant bhi dal liya hai
Sir flush kia tha cooling system ko ?
@@yourDIYneeds yes
Uske baad bhi nahi hua to maybe apko ek flushing agent use karna pad sakta hai , kuki agar apke engine block ki inner side pe ya radiator ki veins me rust deposits honge to wo bhi cooling efficiency ko effect karte hai
2.2 Over cool hota hai highway par reason batao.
Thermostat ya to closed position me atak gaya. Ya phir apki car ka thermostat nikal rakha hai
Bhai mere safari dicor me radiator fan work nhi krta hai ...temp guage middle se aage jaa rha hai ..secondly heat hone pr coolant bhr throw ho rha hai ....haan agr ac on kre toh fan work krte hain. Otherwise work nhi kr rhe khud
Check for blown fuse
@@yourDIYneeds fuse is ok...bhai actually me jab guage beech me aata hai to fan work krna chajiye pr nahi kr rha ...second resevoir me se coolant bhr throw kr rha hai...it means car heat kr rhi hai...fir fan kyu bandh hai....mechanic saying ki gaadi heat nahi kr rhi tabhi fan nahi chal rhe...aisa kaise ho skta hai bhai
@@chaudharygaurav0045 Sir does the radiator fan on immediately when u on Ac or the radiator fan starts only when engine is hot??
Radiator main switch Laga Ho To Uske bare mein bataiye
Radiator main switch ??
Thoda or detail me btae sir ki kya pooch rahe hai
Sar ji meri safari 40 50 kilometre ke baad service dekhai dene lagti h
Sir false code hai , don't worry ,bhot sari gadiyo me hota hai , maybe just a loose connector
बीच बाला गेट नही खुत्न रहा ह्रै लेफ्ट बाला
Engine me knocking ka sound a raha he kya karu ?
Thermostat location should be under turbo
Yes , it is mentioned in discription
इंजिन हिट मीटर मे कैसे देखे और कितना हिट होणे के बाद इंजिन off करे ?
Sir wo bilkul beech me rehni chaiye
@@yourDIYneeds Thank U Sir
Heat light Tata safari
Bhai safari ke bare me agar puri jankari na ho to hame ullu na banawe
20 Saal ho gaya safari chalate banwate problems k bare me jante
Sorry sir mere se galti hui hai
Peeche wali side elbow outflow channel hai video discription me update kar diya hai check kare
Hello Mahesh ji apnsy 1 saval pucy hamari safari mei jab clutch pedal relese karty hai tab veh jatky kyu leti hogi koi
shivam verma ji kisi ache jankar mechanic ki dikhao
Agar clutch release karnepar vibrate kar k gadi initial se movement karti hai to pressure plate change kar dijiye clutch plate check kar lijiyega agar clutch plate acha hoga to use change karne ki koi jaroorat nai hai, mechanic aap ko sare change karne ki salah dega, paise barbad karne ki koi jaroorat nai hai bhai.
Agar apki safari 3.0 l dicor ya 2.2l dicor hai to chalte samay accelerator pedal agar pura release kar k phir dhere se press karenge tab bhi halka sa jerk legi kyunki ye electronic gadiyan hain, aisa old wali 2.0 l wali safari me nai tha.
@@maheshyadava3634 ji thank you for breif detail .
Sir agar transmission khula hua hai clutch ke kaam ke lie to jada badiya yehi hota hai ki aap
Clutch plate
Pressure plate
Clutch bearing
Ye teeno cheje ek sath change kare kyuki har part ki ek life hoti hai and jo parts ek sath use hote hai usually unki life ek jaise hi bnai jati hai
Taki wo ek sath change kiye jae
Waise hi clutch or pressure plate hoti hai , aap bina pressure plate change kiye bina bhi sirf clutch plate change karwa sakte hai but agar thode time baad pressure plate jawab de gai to
Aapko dobara labour deni padegi sirf pressure plate ke lie
Islea ye teeno cheje ek sath change karte hai chahe koi 1 ya 2 khrab na bhi ho
Just as a preventive maintenance step
Gadi pani kha rhi he long root per
Sir a leak most probably
Ya phir radiator cap properly seal nahi kar rahi hai coolant tank ko
1 comment
Tharmostate value dusri side hunda turbo dy niche 😄
vip rackets ye bhai ko puri knowledge nai hai safari k bare me
Ji wahi hai merse galti ho gai ,
Peche sirf elbow outflow channel hai
Engine me knocking ka sound a raha he kya karu ?
Sabse pehle to fuel quality check and fir injectors ko clean