Pinpointing The Bad Battery On a Golf Cart
ฝัง
- เผยแพร่เมื่อ 23 ก.ค. 2024
- In this video we will show you how to determine which is the bad battery on your Golf Cart.
Ebay Store:
www.ebay.com/str/waynesgolfcarts
website :
waynesgolfcarts.com
760 393 1314
waynesgolfcartservice@gmail.com
#WaynesGolfCartService #DIYGolfCarts
Please SUBSCRIBE Below - แนวปฏิบัติและการใช้ชีวิต
Very impressed that this TH-cam man takes the time to answer questions. Alot don't.
Good for you. I don't have an electric golf cart yet, but may someday. Right now i came here because an aircraft tug vehicle with similar battery setup has taken a dive in a few months of non-use and coupled with weird extreme cold in the deep south. When I say extreme, I mean EXTREME ! January 2024.
I'm confident your instructions will work great! Thank you
Great, Thank you!
Thank you so much for these videos appreciated.
👍
Thank you so much for this
Thank you Wayne. Of course, I ended up having to buying a load tester to find my dead battery.
Very informative video. I also have a ez go rxv. Bought it used and batteries are not lasting to long after a charge. Going to check if 1 battery might be bad of if I should just replace all. Thanks again.
👍
Great video, thank you
👍
good luck sir, i check mine, for overheating, you have to check current
Thanks for showing as it is helpful. My golf cart is club cart 36 volts with 6 batteries. Will that also applicable if I plug in the charger, and the reading for 1 of the battery is more than 6.5v or less? My batteries reading without the charger are from 6.2 to 6.5 volts range for each. Thanks for help.
Your batteries are low. What I am saying, is when the charger is running, and 1 of your batteries voltage us twice as much as the others, then that battery is bad.
Great vid man thanks
👍
Thank you! Can you do a video about what cables are connected to the batteries? I am trying to follow the wiring diagram, but I don’t know if the wires are stock. I have two extra wires.... Also, when I hook the receptacle wires up, the green light comes on even if it isn’t plugged in.... help! :)
Amy, tell me what you are trying to do?
Also if you can take a picture of the entire battery area so I can see all the batteries and wires, and text it to me, I can help.
760 393 1314
Thanks good info
Nice, glad you liked it! 👍
Hi Wayne. Thank you very much for the video. I love your content. I have a question, is there need to be any special battery if I have to buy one? I am assuming you just need to find a 12 volts battery similar as the ones used in cars. Thank you
No, car batteries and golf cart batteries are not the same.
You need deep cycle batteries and they are expensive.
@@waynemartin.waynesgolfcart4900 thank you!
👍
What a great idea!!!!
👍it works!
Would a bad battery only let the cart barley move? Got a friends 36volt cart and if I slightly hold the pedal done it will move but not very fast. All the batteries test over 6 volt but one and it’s at 3.4. Thanks
Yes 1 battery will keep cart from moving.
Thanks you amigo firmó Costa Rica i really apréciate this pura vida
👍
Great videos, helpful af🤌🏾
Would be a good idea to tell the people what wire to jump ( neg or pos ) side.😮
@WS-fb5no 👍
@@WS-fb5nome toooo
I keep 2 long battery cables on my cart for this reason and I used wing nuts so I can change it with no tools
👍
I recently bought a used 2012 RXV and was wondering if you like and recommend your watering system that you have on your cart. I learned that back battery is a booger to fill up. Thanks
I am no longer a fan of watering systems, after seeing batteries blow up due to gas fumes getting trapped inside the hoses.
My best advice is to install a lithium battery set up.
Next, just the normal 3 in 1, or 4 in 1 caps that normally come with the batteries.
You can easily reach those rear holes with a Hudson sprayer like I show in my video.
@@waynemartin.waynesgolfcart4900 Appreciate your quick reply and good information. I will check that out thanks
👍
I like your 48 volt charger videos, very informative....thanks
👍👍
do you have a video on how to change that bad battery ? i have a club car with one bad battery how to disconnect and connect it back? thanks
No video, none needed. If you need to replace a battery, being careful, flip tow switch to tow, remove the 2 cables going to the bad battery, and lift the bad battery out. Then drop in the new battery and rehook up the 2 wires. Just don't let the 2 wires touch anything or each other.
My batteries are jumping from 0 to 18v when plugged into the charger. Charger light is on on the charger but doesn’t show it charging light when plugged in. Have 6 12v batteries
Some things don't sound right here. First if your batteries are at zero volts, they won't trigger your charger to Come on.
And if you have 6 batteries at 12 volt each, that's 72 volts.
Exactly what type of golf cart do you have?
When was the last time the cart was driven and last time it was fully charged?
How old are the batteries? You can send me pictures of the charger and the entire battery area so I can see all the batteries and wires.
I have a 36 volt ezgo, time for new battery, been thinking of of with 3 12volts, do you loose in the way of distance and performance this way? Say with 12 volt marine deep cycle battery.
DO NOT USE MARINE BATTERIES FOR A GOLF CART!!
they will only last 2 years max, and your distance sucks.
If you have 6. 6 Volt batteries right now , totaling 36 Volts , and want to replace them with 3. 12 volt batteries you can do that but your distance will diminish because 6 batteries has more lead than 3. 12 volt batteries
@@waynemartin.waynesgolfcart4900 that's what I was afraid of, what 12 volt did you use in your 48 volt?
either trojan or USBattery
I have a 6 48 v Trojan battery cart, each battery reads 8.1, but the total is only 42?
Maybe you have your tester probes on the wrong terminal.
Mathematically doesn't seem possible,.
Send me a picture of your entire battery compartment so I can see all the batteries and wires.
Also indicate where you are placing your probes? Text the pics if easier 760 393 1314
Video on ds hill brake adjust please.
That is a long and tedious process
Thanks for this video. My EZGO txt only lasting about 9 holes and really struggles on uphill. I've checked my 6 batteries at full charge. All measuring 8.6V. Should I measure again when the cart is nearly out of power?
Check volts on each battery and also on the entire pack, check them twice, charge them and let them sit for about 6 or 8 hours or more.
Then drive cart for awhile and recheck all over again, then let's compare the numbers.
@@waynemartin.waynesgolfcart4900 ok so I drove around about 1.5 miles this morning..indicator shows about 2/3 battery but all batteries reading 8.4V and full set at 50V?
Have you thought maybe whatever you are calling an indicator might be bad?
@@waynemartin.waynesgolfcart4900 I wish that were true. The power is definitely down when indicator says so, once indicator gets to 50% the cart can barely make it up any upslope. Cart in question is ezgo txt 2+2 from 2018. One thing is one of the batteries measured 5V at first, but when I rechecked it was 8.6. This happened twice. Once at full charge, once after running down a bit.
If the batteries ever get to 50%, they are considered dead.
How old are your batteries?
Wayne thanks for this excellent video! I have a Club Car cart and it took 7 hours for a full charge. Only used it about 1 hour and it would not start so I charged it. 2nd time time it took about 5 hours to recharge it. It starts now but I must have a bad battery. Can you help me?? Subscribed! 😊😊🇺🇸🇺🇸
Your charging times sounds normal, nothing unusual.
BUT if you can only get 1 hour of driving out of a charge, that might be a problem.
Get a volt meter and check the batteries, before, during, and after charging.
@@waynemartin.waynesgolfcart4900 Thank you sir for the prompt response!!
👍
Will this same techniqye work for solar battery banks? Thanks.
It should
Thank you@@waynemartin.waynesgolfcart4900
I have a 48v cart -4 12v batteries. Put the charger on and the meter only came up halfway. Put battery tester on - all showed good under load. Put the charger on another cart and the meter went to full charge. Any ideas?
Did you try another charger on your cart?
No I haven’t. What would that tell me?
If both chargers worked the same on both carts, then that would there might be something different about your cart.
There may be no issue at all with your cart, if the batteries are fully charged, and charger is acting that way.
I didn’t know you could test them while they were still connected in series? Do you also need to load test them as well to be sure?
you can test them while they are still connected, also can charge individual without removing any wires.
For us basic battery users, should we be moving the battery positions in the rack periodically at all? I was told to move them once in a while
No, no need to move them. I never heard that, why lift those heavy batteries at all.
Hi Wayne
I have a 2017 club car Precedent 48v when I accelerate the club car bucks .. what’s my diagnosis
Thx Tony
Probably batteries
Same question, it’s not a lagging like I read for a bag mcor, it’s more of a slightly aggressive jolt when taking off?
Always look at the batteries first.
I had that problem before and found a loose connection to motor, also tug on wires tying batteries together
👍Thank you!
I would like to find a meter that shows the battery charging on a 8 volt battery
Not following you?
You want to see the charging on only 1 battery? If you have a set of 8 volt batteries, you can check the individual batteries with a volt meter.
When testing voltage on individual batteries , do you disconnect the main ground to the OBC and the main power first? Do you disconnect all the batteries or simply put the negative and positive leads of multi tester on the positive and negative posts of each battery.
don't need to disconnect anything.
Just read each individual battery and then the entire pack
@@waynemartin.waynesgolfcart4900 the six 8 volt batteries are all reading 4 volts. The charger is fine. I had it tested . More than likely the onboard computer not allowing the charger do it’s thing. Tested the charging circuit and everything seems okay.
batteries
Is it okay to change out just one battery? I’ve heard you should change them all at the same time.
Here is my answer, I would say if the set of batteries are all the same age, and are 3 years old or more, then change all at the same time.
Anytime you only change 1 or 2 batteries only, the remaining batteries will pull the new batteries down to their level. Therfore the new batteries will have their life lessened.
Now if your set is say 2 years old and 1 battery goes bad, then yes just replace that battery. And if you do, try to find a used battery about the same age, or if not , you have to buy a new one.
wayne martin that makes a lot of sense. Great vid. Much appreciate
👍👍
I'm trying to educate myself on battery maintenance after our cart died on the way home.
Good! Batteries are the most expensive part of golf cart, so proper care will definitely pay off.
I use cleaned and tightened all my terminals. Without the charger connected, there is about 48 volts across all the batteries. When I connect the charger, the charger meter goes to 15 amps and stays there. That doesn’t sound right to me. Suggestions?
Sounds like it is working correctly. Leave it plugged in, in about an hour the meter should drop to around 10.
Just leave it alone , don't unplug it.
If charger is running after 16 hours, then you can unplug it.
Thanks. That worked. Is it ok to leave the charger plugged into the cart all the time? Does it matter if the cart is in Run or Tow?
no, doesn't matter, run or tow.
As long as there is water in the batteries, you can leave the charger plugged in
Thanks again. Your videos and answers have saved me several hundred dollars this weekend.
Nice to hear, Thank you!!
I wish you had another person filming, I can’t see what you’re putting your leads on to read the voltage.
Sorry, I'm the only 1 here. Look around you will be able to find much better professional filters, sorry.
Can a battery be restored ?
Not really. Not sure what kind of battery you are talking about, but if it has gone dry and the plates exposed, it's a gonner.
How old are those US batteries?
2 years old. The reason the battery went bad, was because the charger was set for the wrong algorithm.
You need to show the placement of the test leads!
Sorry, I thought I was showing and explaining as I go.
Thanks. My RXV doing exact same thing
👍
My charger doesn't have a needle
Why are you telling me this? Most of the newer chargers don't have a needle, but that won't matter , if it wasn't designed with one.?
Not actually able to see what your doing .. I can see that you have a tester but I’m not able to see where your placing the testers
you put your voltage tester on DC volts.
You touch the red probe on the positive battery terminal, and put the black probe to the negative battery terminal.
Appreciate the help but watching the footage was making me nauseous from all the movement
Sorry, I'm not a professional cameraman
Wayne, you need to change your settings to "not for kids". Your videos no longer allow comments or the ability for anyone to save the video to their favorites.
you making me dizzy
sorry, I try the best I can
too dad gum shaky to watch
Sorry, I'm sure you can find a better one on the net.
Buy yourself a camera stand for crying out loud
I guess my video didnt help?
Sorry.
Have some respect for someone that took the time to try to help someone like yourself.
Yeah I mean he's not wrong. A camera stand would help. But it definitely could've been worded nicer.
This has to be the worst camera work ever. I cannot watch it.
Sorry, I was trying to help others, not you.
You really like to throw shit around. Throwing the meter down and dropping the seat. Ease up, homie.
Thank you
I can’t watch it. The videography is horrible.
ok, go somewhere else
this video showed Absoluty nothing................... EDIT first 4 minuets was nothing but fingers and shaking, the last part was helpful, so stay till the end...................
Thanks for the kind words