unless you live a few miles from a coal mine you shouldn't get one of these. Coal is expensive here. We just drove 6 hours return to get 29.21 tonnes of coal. that' s 64,262 pounds of coal. Cost was $51 per tonne for the coal, $83.00 per tonne for carbon tax about $ 4100.00 plus trucking costs. And that's lignite coal too.
The air flow + coil feed which pushes burning coil. The feed pipe and the reservoir are air-sealed so there is no way for the fire to go there. Some boilers have melting safe guard in the feed pipe which melts in case of an excessive heat and lets water from attached reservoir to flood the feed pipe. It shuts down by stopping the fan. With no air feed the fireplace dies out.
I have similar boiler like this. It's very good system of heating. I like it, but i have problem with right settings for higher efficiency. I have to clean boiler every day from ash.
We had a wood pellet stove that had the same construction. The problem I had was the pellets would crust up and not burn, or the pot would coke up to the point of jamming the auger. I was glad to stop using that thing.
In this case you should use an UPS for the pump to keep circulating the boiler's water or if you haven't one, the thermostatic valve which is mandatory under the regulation will open when the water's temperature sets a limit of 90 degrees and then an automating filling unit will supply the system with cold water. So no worries about this.
Fire will die. Fuel tank is sealed with rubber gaskets. So there is not enough air to support fire. In case of corrosion of the chest or if you leave tank hatch open you will get a lot of smoke in the room. This is not big problem if the worm drive is working. When enough heat is detected it will work until all hot coal is expelled out of the pipe. If you are really worried about the fire. You can mount water tank in the middle of the worm drive. There is a cap that will melt if enough heat and water will stop fire. Had one in my house. This is piece of trouble. Use only if you are far from gas pipe or you can't afford heat pump. Lots of mess. And you need proper settings to coal you get. Otherwise expect unburned fuel. "Elephant foot" growing in the burner instead of ash. Also coal needs to be perfect dry. Otherwise box will corrode in 2c seasons. As i said. Last resort technology.
Ini cara yang tidak aman, dimana api batu bara bisa menjalar melalui skru, ini akan terjadi kembaran hebat Gunakan coal feeder dan traveling grear untuk mengatasi hal itu
O que não mostra e a dificuldade de fazer limpezas. Conheço uma melhor com limpeza altomatizada VC só tem que tira um saco com .está VC tem que limpar os tubos .
Как вариант он определяет увеличение нагрузки на шнек через увеличение тока двигателя и предпринимает различные действия в зависимости от программы. Например, даёт несколько раз реверс и если нагрузки не пропадают то встаёт в аварию и может сообщить об этом.
Ну а если имеете ввиду угол трубы под самой горелкой то там такое маловероятно, если топливо пролезло через шнек то оно прекрасно выдавливается на верх
Every 10 days you have to work on this thing and it still needs electricity to run, what is the point I don't get it? My gas furnace needs no work, just set the thermostat and that's it.
It's for places where you don't have a cheap supply of gas. It happens. I live in an area where natural gas lines don't exist yet, so the demand is taken up by propane businesses who set up a big tank of propane at *each* house that's regularly refilled by trucks. If that doesn't exist, the next best solution is solid fuel. Of course, solid fuels are usually cheaper per BTU than propane but marginally more expensive than natural gas. That's offset by the maintenance needed just to run it. Most people go for the ease and convenience of liquid or gaseous fuels. Electrical heating is the LAST resort as it's usually the most expensive. However, electrical heating is competitive when running a heat pump with a COP of 2 or more, however, those don't work very well in colder climates unless you get a Ground-source unit instead of an air-source unit --- and those get very expensive fast.
Thing with wood pellets, they crust over and clinker, so they won't burn. Coal has a far higher heating ability, you can get it wet without destroying it, it makes less harmful dust, burns for longer, and the ash is a lot less dusty and flaky. Generally easier to use.
Там почему-то самой золы как таковой мало, весь углерод на 99,9% выгорает, уголь кстати тоже нужен обогащенный, но бл.. пыли и Сади от него это ад!) Я видел такой в работе, котельная вся черная как угольный ящик и это буквально лет за пять...
Great video - I love the independence solid fuel gives you.
excellent!
The animation of Gastric Burner which is very good, I was inspired by the greetings from Jakarta
Bb
Very good animation😊
May i ask what software is used for this kind of animation thank you very much and more power
unless you live a few miles from a coal mine you shouldn't get one of these. Coal is expensive here. We just drove 6 hours return to get 29.21 tonnes of coal. that' s 64,262 pounds of coal. Cost was $51 per tonne for the coal, $83.00 per tonne for carbon tax about $ 4100.00 plus trucking costs. And that's lignite coal too.
Very helpful
Which software is used for animation
Thank you
hello sir!
now im making video that compareing old boiler and condensig boiler.
if possible, can i use this video?
What is the mechamism that keeps the fire from traveling up the feed pipe, and how do you shut it down?
The air flow + coil feed which pushes burning coil. The feed pipe and the reservoir are air-sealed so there is no way for the fire to go there. Some boilers have melting safe guard in the feed pipe which melts in case of an excessive heat and lets water from attached reservoir to flood the feed pipe.
It shuts down by stopping the fan. With no air feed the fireplace dies out.
@@petrpohnan875 thank you.
instaBlaster.
Awesome
Are these available in the United States?
អរគុណThank👏
How is temperture of carbone stone
I have similar boiler like this. It's very good system of heating. I like it, but i have problem with right settings for higher efficiency. I have to clean boiler every day from ash.
We had a wood pellet stove that had the same construction. The problem I had was the pellets would crust up and not burn, or the pot would coke up to the point of jamming the auger. I was glad to stop using that thing.
Its a solid fuel..ash accumulation is inevitable
Сколько к ват у тебя аппарат ???
На сколько кв. М отапливает ????
👍👌
Szkoda ze nie ma jrszcze 1 drzwiczek. By mozna np wlożyć drzewo
Не плохо
自動給炭はロマン。
👍
What gonna happen is electricity is down for serval hours? Will the fire go into storage box?
In this case you should use an UPS for the pump to keep circulating the boiler's water or if you haven't one, the thermostatic valve which is mandatory under the regulation will open when the water's temperature sets a limit of 90 degrees and then an automating filling unit will supply the system with cold water. So no worries about this.
Fire will die. Fuel tank is sealed with rubber gaskets. So there is not enough air to support fire. In case of corrosion of the chest or if you leave tank hatch open you will get a lot of smoke in the room. This is not big problem if the worm drive is working. When enough heat is detected it will work until all hot coal is expelled out of the pipe. If you are really worried about the fire. You can mount water tank in the middle of the worm drive. There is a cap that will melt if enough heat and water will stop fire. Had one in my house. This is piece of trouble. Use only if you are far from gas pipe or you can't afford heat pump. Lots of mess. And you need proper settings to coal you get. Otherwise expect unburned fuel. "Elephant foot" growing in the burner instead of ash. Also coal needs to be perfect dry. Otherwise box will corrode in 2c seasons. As i said. Last resort technology.
Классный котёл
Турбина и двигатель шум на весь дом
Меня как-то смущает надёжность подачи топлива через шнек, как система отреагирует если топливо будет нагреваться на подаче, до топки.
Супер
How much?? How the price????
👍🏿
It will be nice if mini electric turbine include in this design and help lower electric bill from grid.
Please name the animation program🌹
Deme 10
👍👍👍👍👍😄
Szajs
Ini cara yang tidak aman, dimana api batu bara bisa menjalar melalui skru, ini akan terjadi kembaran hebat
Gunakan coal feeder dan traveling grear untuk mengatasi hal itu
Terimakasih masukkannya🙄🙏
Yanarken kömür doposuna sıçrama tehlikesi olmazmi,ateş elezondan geri geri dopoya gider tutuşur,
O que não mostra e a dificuldade de fazer limpezas. Conheço uma melhor com limpeza altomatizada VC só tem que tira um saco com .está VC tem que limpar os tubos .
Q es esto
А если уголь закусит между шнеком и углом?
Как вариант он определяет увеличение нагрузки на шнек через увеличение тока двигателя и предпринимает различные действия в зависимости от программы. Например, даёт несколько раз реверс и если нагрузки не пропадают то встаёт в аварию и может сообщить об этом.
Ну а если имеете ввиду угол трубы под самой горелкой то там такое маловероятно, если топливо пролезло через шнек то оно прекрасно выдавливается на верх
@@batonagmitov1860 я имел ввиду имено шнек и угол бункера, тоде думал о реверсе.
Думаю он разломает уголь, шнек из толстого металла+ момент очень большой через редуктор.
Он он обязательно закусит.
Every 10 days you have to work on this thing and it still needs electricity to run, what is the point I don't get it? My gas furnace needs no work, just set the thermostat and that's it.
It's for places where you don't have a cheap supply of gas. It happens. I live in an area where natural gas lines don't exist yet, so the demand is taken up by propane businesses who set up a big tank of propane at *each* house that's regularly refilled by trucks. If that doesn't exist, the next best solution is solid fuel.
Of course, solid fuels are usually cheaper per BTU than propane but marginally more expensive than natural gas. That's offset by the maintenance needed just to run it. Most people go for the ease and convenience of liquid or gaseous fuels. Electrical heating is the LAST resort as it's usually the most expensive. However, electrical heating is competitive when running a heat pump with a COP of 2 or more, however, those don't work very well in colder climates unless you get a Ground-source unit instead of an air-source unit --- and those get very expensive fast.
@@BrokenLifeCycle Very good explanation!!!
could the coal be replaced with wood chips and move through that tube.
it should be
Thing with wood pellets, they crust over and clinker, so they won't burn. Coal has a far higher heating ability, you can get it wet without destroying it, it makes less harmful dust, burns for longer, and the ash is a lot less dusty and flaky. Generally easier to use.
no. power goes out fire smolders back through auger to storage bin. With coal fire goes out in feed auger.
where can i buy this???
check this address: www.kozlusan.com/en/products/1009/solid-fuel-fired-boilers/1005/solid-fuel-fired-boilers-kyk-series.aspx
th-cam.com/video/cAWXC5l2dqI/w-d-xo.html
www.defro.pl
у меня один вопрос как тушыть эсли свет выключат. кипеть
Если вентилятор не дует сам потухнет плюс клапан сброса давления...
Снегом легко тушится, после водой
Сразу водой нельзя, ожоги можешь получить
Там показывает же когда свет гаснет он тухнет без кислорода
Дернул за веревочку и завел генератор или электростартер или ИБП. Под лежачий диван вода не течет.
Хорошо, но в течение 10 дней от золы Пупкин будет чистить?
Я могу почистить, есле надо.
спустя почти 6 лет попало в предложение
Давай я почищу.
За 500 рублей я могу ещё и стёкла протереть.
😂
@@user-wr2jz6fs6s конкурент 😅
Там почему-то самой золы как таковой мало, весь углерод на 99,9% выгорает, уголь кстати тоже нужен обогащенный, но бл.. пыли и Сади от него это ад!) Я видел такой в работе, котельная вся черная как угольный ящик и это буквально лет за пять...
The fire will burn all in the side box
Sıkıntılı helezondan ateş depoya yürürse🤔
А сколько стоит
allegro.pl/oferta/piec-co-piece-kociol-24-kw-kotly-duo-2-paliwa-9910597239
Токога катла уже делийт онас
Салам жахангир где это делайт увас это где
@@jaboralihidiraliev7798 алекум салам город наманган ситомистм 1400долир
@@johongirmramor9506 жахангир 1400$ ЭТО САМАДЕЛНИЙ ИЛИ ЗАВАТСКАЯ МОЖИЖ СКАЗАТ
@@jaboralihidiraliev7798 самаделная